2001 clio 1.2 16v sunroof leak - Page 6 - Renault Forums :: Independent Renault forum

LinkBack Thread Tools Display Modes
post #26 of 79 (permalink) Old 12th June 2009
owenstringer's Avatar
Join Date: Jun 2009
Posts: 160
Nominated 0 Times in 0 Posts
TOTW/F/M Award(s): 0
Thanks: 1
Thanked 4 Times in 4 Posts
Send a message via MSN to owenstringer

as said above you need to remove the sunroof including plastic black lining and aply an adhesive silicone is good and the re install the sunroof. your prob lem is not with the drains they are there to iliminate the noise and rattle mostly, renault will tell you to buy 1 of there upgraded sunroom liners for 250 to 300 quid. it is a common problem and they arent willing to admit it. so a bit of silicone will do the trick. it should take you about 2 hours with confidence. hope this helps
Currently in owenstringer's garage:
Megane 2 1.6 dynamique 2004
owenstringer is offline  
Sponsored Links
post #27 of 79 (permalink) Old 12th June 2009
Junior Member
Join Date: Nov 2006
Posts: 6
Nominated 0 Times in 0 Posts
TOTW/F/M Award(s): 0
Thanks: 0
Thanked 0 Times in 0 Posts
Originally Posted by bawjaws View Post
hi all been looking on the forums for a solution to this but the are all for the mk1's. i have a manual roof on a 51 plate all the drain channels are clear tested with coloured water. have heared that it may be the fitting between the roof and sunroof frame. thinkin bout dismantling and siliconing it to the bodywork but want to hold off incase a less perment solution is available. any help apprecitaed

ps soz bout spelling.

pics would help if poss
I think you will find the problem is the sunroof to roof bond which has failed.Silicon alone round the perimeter of the sunroof will not effect a seal for long as the roof to frame bonding will be broken when the car shell twists when in motion,(i take it your sunroof is creaking also)?? unfortunately even after fixing the roof you will still get the creaking,maybe not as bad,but if you put a blob of vaseline or silicon grease on the catch bar (under the red button)that seems to work for a while. However to fix the roof ,you can do it without removing all of the headlining.Remove the glass panel,remove the two trims down the left and right of the windscreen,pull back both door seals,remove sunvisors,roof handles,seat belt top bolts/mounts,roof light panel,trims on both sides round side windows(if 2-door),if 4 door remove any trim panels / door seals,so you have access on both sides to the roof lining,also remove the edge trim from the sunroof.You should now be able to pull the roof lining GENTLY away from the double sided tape holding it to the roof.You will find there is a line of tape at the front somewhere near where the visors fit and another just behind the sunroof handle.
If you loosen the tape gently you may be able to restick it in place when you reassemble,if not you probably wont need it anyway as when everythings back in place the lining will be held securely.Now you should have enough access all way round the underneath of the roof to unfasten the (if I remember rightly 16x8 mm nuts)from round the perimeter of the roof and the bottom plate will then be able to be removed from the sunroof.At this point you will be able to see exactly where your roof was leaking from i.e the roof bond.Pull the sunroof outer frame from the roof and clean the old tape which you will find sticking to it off ,this is the problem ,the old tape is not thick enough,it gets compressed and no longer stops water entering.(Behind the sunroof to the rear of the car there is a roof support plate,if you think of the roof shape in profile as an upside down U shape,this plate is more of an upside down V shape inside the U shape,as it were. If Renault were to make this plate to the same profile as the roof and bond it to the roof,as they do to the roof support plates round the screen,the sunroof would not creak as it would stop any movement of the roof panel,thereby strengthening the top of the car,eliminating any movement.You now need a roll of double -sided automotive trim tape,the one i used was 8mm wide by 1 mm thick,this is used for sticking badges /trim mouldings to the outside of vehicles,any automotive /body shop supplier should have this in stock.I also used some neoprene single sided door seal 10mmX10mm.
Clean the roof opening and frame,stick the double-sided tape to the perimetre of the roof just in line with the edge of the opening,and also to the underside of the frame to the inner edge of the frame,so in effect when you replace the frame into the opening you will have 2 lines of adhesive tape bonding to each other,completing the seal,this alone will work as its twice the thickness of tape Renault use.I then used the single sided tape ,around the metal frame which bolts to the underside of the sunroof frame.This tape does not stop water entering,but acts as a vibration damper for the framework and stops the sunroof bolts loosening,and then they let water underneath the frame,which then finds its way onto your lap etc.As I say you dont have to fit this tape,you could just use the two lengths of double-sided which make the actual water seal,I just used it as a belts and braces move.Bolt the frame together,replace all your trim/seals etc and then sit back and wait for it to rain,I think youll find water now doesnt enter from this particular area anymore.Allow a full day to do this,preferably a dry one!!,and dont over tighten the 8mm nuts when reassembling and snap any ,just tighten evenly all the way round.
Currently in colinho's garage:
clio 1.5dci
colinho is offline  
post #28 of 79 (permalink) Old 13th June 2009
Veteran Member
Technical Supremo
Lagdti's Avatar
Join Date: Dec 2005
Posts: 40,429
Nominated 2 Times in 20 Posts
Nominated TOTW/F/M Award(s): 18
Thanks: 149
Thanked 1,103 Times in 942 Posts
Hello Colin,welcome to the forum.

Excellent first post,thank-you very much for your input.

I'd rather push my Alfa than drive a BMW....
Currently in Lagdti's garage:
2004 Saab 9-5 HOT Aero and a 2001 Audi A3 1.8 Turbo
Lagdti is offline  
post #29 of 79 (permalink) Old 16th July 2009
Junior Member
Join Date: Jul 2009
Posts: 3
Nominated 0 Times in 0 Posts
TOTW/F/M Award(s): 0
Thanks: 1
Thanked 0 Times in 0 Posts
I am also experiencing the same problem. HELP.
Currently in aslamshaikh04's garage:
2002 Renault Clio Extreme 1.2
aslamshaikh04 is offline  
post #30 of 79 (permalink) Old 9th August 2009
Junior Member
Join Date: Jul 2009
Posts: 23
Nominated 0 Times in 0 Posts
TOTW/F/M Award(s): 0
Thanks: 2
Thanked 3 Times in 3 Posts
Smile dont rip the roof out just yet

before ripping the car to bits its worth taking the interior light out on a rainy day and making sure its not the ariel leaking as it was on ours. I was just about to rip the whole roof out then noticed it coming down the bolt that secures the ariel. undid it and sealed it up. Dry as a bone now!
Currently in daznjo's garage:
clio 1.2 sport and mk4 1.4
daznjo is offline  

16v , clio , leak , sunroof

Quick Reply

Register Now

In order to be able to post messages on the Renault Forums :: Independent Renault forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Please enter a password for your user account. Note that passwords are case-sensitive.


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:


Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.

Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page
Display Modes
Linear Mode Linear Mode

Posting Rules  
You may not post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

For the best viewing experience please update your browser to Google Chrome