Independent Renault Forums banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-17 of 500 Results
  1. Engines
    Finally got to the bottom of a problem that has bugged me for a while and thought I would share it for reference as I couldn't find the exact solution online (Might be out there but I couldn't find it at least) Had a clicking noise for the past few months coming from the top of the engine...
  2. Ask the Experts
    What is this unit used for on the EGR? Where does the other side of the vacuum pipe attach too?
  3. Ask the Experts
    Hello, Scenic 1.5dci from 2007 crancks but won't start after egr clean, all we did was remove egr and hose that goes to intercooler so we can get to egr valve. We checked egr and it opens and closes, we tried disconecting battery for 10 mins, car doeant show any erros on dashboard or does it...
  4. Engines
    Hi all, had a good look through the forums but cant seem to match the fault so new post it is :) I bought a master in October and it didn't run right, almost as though it had no turbo, however after stripping her down i found the EGR valve was dead as a dodo so I replaced it, now the van ran...
  5. Ask the Experts
    I've read posts on this but can't find one that relates to mine. I have a grand scenic 1.5dci (2011) with 103k miles. So seemed to be ok, then hubby went out on motorway and said it lost power and said check injectors, red message said engine failure hazard. At the same time the check ESP light...
  6. Engines
    The engine has undergone an extensive service & overhaul during the winter: There is a new high pressure pump, new injectors, a new MAF-sensor and more. The car and engine were working well. But then the car started to emit a lot of black smoke when accelerating more heavily from idle ja and...
  7. Electronics
    Hi my egr wiring has chafed through at the plug, Iv'e got the small pins out and soldered the wires together but like an idiot forgot to check which colour went to which number on the plug, any help would be most appreciated . Alan
  8. Engines
    Found a noise coming from the engine area whe i press the accelerator pedal, ive found a bracket that sits on top if a spring on the egr cooler has broken off. It has a small whee and crimped wire around it, i am assuming that there is some kind of flap inside thats now rattling about, anyone...
  9. Engines
    1.5 DCI 70 on a kangoo. Took the EGR our to clean it as it was well gunked up (will be getting the turbo looked at next!) and found I can't move the valve at all by hand It's the all-in-one type as per the picture attached so I assume the vav le is directly attached to the actuator - should...
  10. Engines
    I have a Modus DCi 2008, the battery is draining due to the EGR valve continuing after the car has been switched off and locked, local garage replaced EGR valve as they said this was the problem but not resolved and they have given up and told me to go elsewhere, any ideas, the noise from the...
  11. Engines
    Hi everyone. 2005 Laguna 1.9dci sports tourer with 304,000 miles. I***8217;m cleaning the EGR due to oil and bit of hesitation, don***8217;t think it***8217;s ever been out, but have 2 problems. Firstly I can***8217;t get the wiring clip off? Is there a place on the side or top to push a screw...
  12. Exhausts
    Has anyone had any experience blanking EGR system on Renault trafic 1.6 (r9m-408) 2014 It takes egr feed from just after DPF, theres then a cooler, then low pressure solenoid valve, followed by final EGR valve. There are no pressure/flow sensors on EGR system after dpf. There is also an...
  13. Engines
    Hi all I just purchased my first van, a 2003 Trafic dci 100, the first thing I noticed was how gutless she is! I searched and found some tips on performance on here and I have blanked off my cars EGR, so I went to do this on the van and it will not twist at the middle join, even in a vice with a...
  14. Engines
    Had lots of interesting advice and discussion on blanking egr,when I posted as pisces63 (forgot password) Finally decided to do it,but body of egr valve broke on trying to remove,so left in place,however egr pipe broke several thousand miles later,and the studs holding the egr pipe...
  15. Engines
    Renault Clio Kangoo dci 1.5 idle dropping out on cold start. When the engine warms up a little its working fine unless you step on the gas fully on load and the engine will go to limp/safe mode. Newly refreshed injectors battery needs replacing although I do not think that it has anything to do...
  16. Exhausts
    Not directly related to Renault but more to the F9Q 1.9 DDis Diesel. Supplied to various other car manufactureres. Mine is in a Suzuki Grand Vitara in Australia and has many of the same issues for driving style EGR DPF then Turbo. So for those who are looking from a different perspective how to...
  17. Engines
    Just bought some wynns egr valve cleaner ready to spray into the valve to see if there’s any quick improvement. Problem is I can’t for the life of me see where I can get into it to spray it. See attached photos Looks like I may have to remove it completely, which will be a bit more time...
1-17 of 500 Results
Top