Independent Renault Forums banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-16 of 51 Results
  1. Engines
    fitted recon pump and recon injectors blanked 3 pipes off from new fuel filter and sucked on pipe and no leaks but air in inlet pipe and froffing from return car ticks over and then a fuel knock can be heard and cuts out intermittently diag showing low fuel pressure and High fuel pressure in...
  2. Engines
    I recently tried fitting a tuning box on my 2008 clio 1.5 dci dymanique. When i tried to split the sensor connector on the bottom of the fuel rail the whole half of the connector snapped away from the fuel rail I tried tonrelocate it on the rail but when i try to start the engine i get the...
  3. Engines
    According to OBD11, the following fuel pressure is shown: 800rpm - 3364psi 3000rpm - 6328psi Is this within normal range?
  4. Bodywork
    Hi guys, I know I’ve been posting a lot recently, trying to save money and learn tips/tricks. I’ve just disassembled my drivers side door everything is off it’s getting dark and I can’t get the scissor rail thing out? I’ve tried looking everywhere for info and none? Everything is unbolted and I...
  5. Engines
    Just rebuilt the cylinder head on a customers 2001 scenic RX4 with 98k on the clock after the auxiliary belt failed and threw the cambelt off around 6-7 months ago (been parked up ever since), she was originally intended to scrap the vehicle but with winter fast approaching and the need for a...
  6. Engines
    Just been to visit my parents over in France and their 2002 scenic dci had developed a fault whereby it would occasionally cut out going around roundabouts or at junctions, requiring the ignition key to be turned off and on before it would fire up again and drive normally. After a few tests I...
  7. Engines
    Hi, I've been doing some diagnostics on my scenic II due to the traditional no power issue. Looking at the fuel rail pressure, it's telling me it's at ~ 40,000 PSI I know these are high pressure systems but 40,000 seems rediculously high. Can anybody tell me if this is correct and if not what...
  8. Engines
    Can anyone please advise on the correct value for the tightening torque of the bosch 0281002522 pressure sensor as fitted to my 2003 Trafic dci 100. I dont want to just pull it up as tight as it will go as I have heard of instances of these sensors shearing:mad: as a consequence of over...
  9. Engines
    2004 master 2.5 dci currently reading between 29 k and 31k on idle, is this low as my old vivaro used to read around the 36k mark and that was a 1.9? Thanks in advance
  10. Engines
    Does anyone know the difference between df4 712 and df4 722 engines. Would i be right in saying that the injector rail is different and on the 722 engines the injector loom is replaceable and on the 712 engines the whole top engine loom needs to be replaced if the injector loom needs to be...
  11. Engines
    Hi, I've just been quoted £760 for a new fuel rail and lines, my car kept going into limp mode with check injectors appearing on the dash, anyone had this problem before?
  12. Engines
    Hi. I am new to the forum and this is my first post, so I apologise if I get anything wrong. I have an '04 Scenic 1.9dci that I had to get recovered the other day. Whilst driving the STOP and service lights came on and Injection failure message came up on the dash. The car now wont start...
  13. Engines
    hi can anyone tell me what the rail pressure should be on tickover i am useing renault clip, 212 bar varies to 380 bar but ticks over really smooth just wont rev? struggles at 2500, (bosch pump) goes up slightly to around 420 ish at 2500rpm, could it be a faulty pump, is there any common faults...
  14. Interiors
    I have a 2007 Espace but will be using it for a long trip soon. I will remove the back seats to create as much space as possible but wondered if there are any gadgets available to enable the floor rails to be used to as anchor points for cargo or items in the rear. I had imagined something would...
  15. Engines
    Hello, I am experiencing problem with the Renault Trafic 2.5 liter diesel common rail engine ( G9U 630 ) with 107kw power. At first the engine could not start so I changed Fuel Rail Valve(was broken), fuel filter and fuel pump(was broken too). That resolved the problem with the engine start...
  16. Electronics
    hi all i have 2005 trafic 1.9dci 100, fault code is p0032 pointing to fuel rail sensor , how can i check this and what socket size removes it? ive guessed it to be 27mm long socket?
1-16 of 51 Results
Top