Independent Renault Forums banner

rebuild

  1. Help to buy Renault Scenic RX4 Power steering rebuild kit

    Cars & motoring
    Hi All my Power Steering fluid is leaking and I am trying to find where to purchase a power steering rebuild kit. Would anybody know an online store?
  2. clio 182 F4R rebuild

    Engines
    Hello peeps, So I have a 2005 clio 182 that has been running problem free for 4 years - just regular oil and filter changes (DIY) and last year into a pro for cam/aux belt changes. 14 mths later the aux belt goes while over-taking up a hill (so flat out) ... with it goes the cam-belt and all the...
  3. 2009 Clio GT Gearbox Rebuild

    Transmissions
    Hi All I have a 2009 Clio 1.6 VVT GT 6 Speed Recently 3rd and 4th gears have been crunching so have taken the plunge and decided to strip box and replace 3rd and 4th syncros. Gearbox is now out of the car and have split the casing, removed input and output shafts. On top of input shaft is a...
  4. Ignition Lock Rebuild

    Electronics
    Hi there, the return spring inside my Clio 2002 ignition barrel failed today so I have to return the key manually to position 2 after starting or else the starter motor keeps turning. If I get a replacement barrel from a scrappy or ebay say with matching keys, is it possible to get into the...
  5. megane 1.4 16v k4j won,t start after head rebuild

    Engines
    hello there I rebuilt megane 1.4 16v k4j 730 after timing belt failure but won,t start it turns freely get popping noises if I hold the throttle wide open but that's it coils maybe ? I tried to tow also but it wouldn,t start either then got check injection and electrical fault come up on dash...
  6. F9Q812 engine rebuild

    Engines
    Hi everybody I need a bit of advice on engine rebuild of the engine on my scenic. The engine is seized due to knackered pistons it was burning oil, smoking and eventually sized up but this was not whilst I owned the car so now I paid nearly nothing for the car and wouldn't mind having a go at...
  7. Trafic 1.9dci wont start after head re-build **Fixed**

    Engines
    Hi all, Been busting my nut this last month when my trafic threw the aux belt into the cam belt. Top pulley has sheared and a couple of the valves didn't sound too great, so I stripped the head off. I've changed the valves and rebuilt the head and now rebuilt the whole engine. Anyway on...
  8. No ignition lights after engine rebuild

    Engines
    Hi all, I'm in need of some advice, I bought a grand scenic 1.9 dci 2005 on the cheap as the engine had failed, crank had grabbed a shell. So stripped it all out rebuilt the engine f9q 812, refitted, fitted the battery and went to start but no ignition lights, just immobiliser blinking at me. I...
  9. No ignition lights after engine rebuild

    Electronics
    Hi all, I'm in need of some advice, I bought a grand scenic 1.9 dci 2005 on the cheap as the engine had failed, crank had grabbed a shell. So stripped it all out rebuilt the engine f9q 812, refitted, fitted the battery and went to start but no ignition lights, just immobiliser blinking at me. I...
  10. Kangoo won't start after rebuild

    Engines
    Hi any help would be much appreciated, I have a kangoo 1.9d with 120k, the water pump went the other day and before I'd realised it had seriously overheated. Anyways I had it recovered and stripped it down, got the head skimmed and put it all back together. I've aligned the crank and cam with...
  11. Oil leak following rebuild 2002 Scenic Megane 2 litre automatic

    Engines
    In my last postings I discussed how my 2002 Scenic Megane 2 litre automatic cam belt had snapped and written off the engine. It was rebuilt in January and running well since then However, last week the oil warning light came on and the level was below minimum (cold engine flat surface) I...
  12. J8S 2.1 TD rebuild and tune up

    Engines
    Hi all... I have finally managed to install my J8S TD in my Jeep CJ7 and all is running OK except that I have a small oil leak from the rear of the engine, which I assume is from the rear crankshaft bearing. I have renewed the sump gasket and very carefully installed it with silicone so I'm...
  13. K9K Engines

    Engines
    Hello everyone. I am hoping to find out some info with regards to K9K engines Last week my megane 2006 106 1.5DCi decided to throw a conrod out of the block for unknown reasons to me. My question is will any K9K engine fit my car and allow me to use all my current anciliaries. I believe my...
  14. 1.5 dci smoking after engine rebuild

    Engines
    hi all just spent a fortune having my 54 scenic 1.5dci repaired. had new alternator, new timing belt kit, replacement recondition cylinder head, 4 replacement injectors, new oil filter & fuel filter. had it back on the road for a week and its started to smoke heavily intermittently. starts...
  15. Rebuild a turbo

    Engines
    How easy is it to rebuild a turbo I see you can buy new internal complete on e bay for approx 110 pounds anyone with experience of this Dave
  16. Engine management light on after rebuild.

    Engines
    Hi all Have completed rebuild of 1.4 clio 16v k4j engine after Cambelt failure. The good news it actually runs. The bad news engine management light now is either on or flashing , engine runs but seems a little lumpy and low on power at tick over, as soon as revs pick up their seems plenty of...
  17. Scenic 1.5 dCi 100 rebuild

    Engines
    Hi All, I'm in the process of rebuilding the engine for my Scenic, does anyone want me to start a thread on my progress and if so where? Steve.
  18. Clio 1.5 dci Lumpy idle/ low compression?/Possible misfire?

    Engines
    Hi, just like to say what a good forum this having just signed up, lots of helpful users and well set out site. I did a return journey to Newcastle of 250 miles on wednesday evening and the Clio2 (1.5dci 65) ran well with no signs of any problems or untoward noises. When the car was started...
  19. 1.5 Dci no start after rebuild

    Engines
    Hey folks Just wanting to find out if anyone here has had any experience of serious non-starting after engine rebuild. I know 100% that all of the injectors went back into the same cylinder, so thats not the issue, and I am getting fuel flow (pressure not known) I did have an issue to start...
  20. scenic 1.9 dci 2001 turbocharger rebuild kit

    Engines
    Hello, My turbocharger , in scenic 1.9 dci, year 2001 is leaking oil. I saw many rebuild kits at price of 30.00, but i dont know the type of turbocharger. I intend to dismantle a turbo in garage, and to rebuild by DIY job. Can you please advice me which type of this kit to buy, what is the...
Top